Welcome to Emissions Control Guide
Emissions Control System Leak Article
. For a permanent link to this article, or to bookmark it for further reading, click here.
How The Emissions Control Canister Works
from:The emissions control canister contains charcoal and is designed to prevent the gasoline vapors emitted by the gasoline in the fuel tank of automobiles from entering the atmosphere. The emissions control canister is mounted in a non-conspicuous, safe place, usually in one of the rear wheel wells. When the car’s engine is not running the gasses radiating from the gasoline in the fuel tank are stored in the emissions control canister. The vapors are stored within this charcoal filled canister to be purged and burned when the running engine has reached certain predefined conditions. The emissions control canister in some automobiles will store any liquid fuel that has entered the canister in a reservoir designed into the bottom of the canister. The liquid fuel is stored in a separate reservoir to protect the integrity of the charcoal contained in the main emissions control canister housing.
There are three control methods used to purge the vapors from the emissions control canister, the first of which is controlled by the throttle’s position without a valve on the canister. A throttle body system may have a vacuum connecting the canister to a ported vacuum source designed as part of the throttle body. At any level higher than idle, the throttle may be positioned in will fresh air will be pushed into the emissions control canister. When the fresh air is added to the canister, it causes the fuel vapors to be purged into the throttle body through the port at a constant rate.
The second control method is by a vacuum valve that modulates the flow, also by throttle position. A diaphragm valve on the top of the canister opens when the vacuum ported from the throttle body opens it. When this valve is opened oxygen and fuel vapors are drawn into the intake manifold normally through the same port used to control the PCV system. The valve cycle under this control cycle is considered to be “slaved” to the throttle. The more you open the throttle the more the emissions control canister is purged.
The last of the three control methods is when the ECM activates a solenoid valve on the emissions control canister. This control method may be used only when the following pre-determined conditions are reached: The engine is within normal operating temperature, the engine has been running for a pre-determined amount of time, the vehicle speed has exceeded a predetermined rate and the throttle is open more than a predetermined level. As the solenoid is activated, full vacuum is applied from the manifold to the diaphragm of the purge valve, opening it completely. When the diaphragm fully opens the valve, fresh air rushes into the canister at a high rate, quickly purging the fuel vapors. When this happens, the ECM solenoid valve on the emissions control canister purges the canister.
Emissions Control System Leak Specific links
Emissions Control System Leak News
Public meet set tonight on enviro review - Pueblo Chieftain
Public meet set tonight on enviro review Pueblo Chieftain It has a detonation chamber, an expansion chamber, and an emissions control system. The weapons are wrapped in explosives and blown up. Using the DAVINCH, the munitions placed inside a chamber are destroyed by explosives through the heat of a blast and ... |
15% ETHANOL FUEL RAISES CONSUMER CONCERNS; NEW STUDY DEMONSTRATES VEHICLE ... - Power Engineering Magazine
15% ETHANOL FUEL RAISES CONSUMER CONCERNS; NEW STUDY DEMONSTRATES VEHICLE ... Power Engineering Magazine A range of engine operating parameters was monitored during the test, including cylinder compression, valve wear, valve leakage, emissions and emissions control system diagnostics. Two of the engines tested on E15 had mechanical damage. |
BP Must Pay $400M for Indiana Refinery Emission Controls - Environment News Service
 Environment News Service | BP Must Pay $400M for Indiana Refinery Emission Controls Environment News Service WASHINGTON, DC, May 24, 2012 (ENS) - BP North America Inc. has agreed to pay an $8 million penalty and invest more than $400 million to install state-of-the-art pollution controls and cut emissions from the company's petroleum refinery in Whiting, ... BPNA settles environmental charges at Whiting, Ind., refinery |
Eastman Chemical Company Receives Energy Efficiency Awards for 19th ... - Reuters
Eastman Chemical Company Receives Energy Efficiency Awards for 19th ... Reuters That's enough energy to power 16000 homes and eliminate greenhouse gas emissions from over 60000 cars! "These eight winning projects exhibit innovative examples of control strategy modifications, trials with new types of equipment, creative process ... |
Japan Nuclear Operator Conducts Check on Risky Unit - Wall Street Journal
Japan Nuclear Operator Conducts Check on Risky Unit Wall Street Journal The investigation—the first of its kind to take place at Fukushima Daiichi since three reactors spun out of control 14 months ago—also underscores how unclear conditions at the plant remain, and how deep the distrust in Japan's nuclear industry runs. |